205-26 Exhibit.pdf

West Orange Public Works Department Bus Preventative Maintenance Scheduled Inspection Chassis Service Requirements Gas Powered The preventative maintenance scheduled inspection provided chassis services shall be performed in accordance with i the manufacturer's maintenance specifications. The following shall include but not be limited to: A. Preventative Maintenance at 5,000-mile intervals $ 1, Engine Oil - Drain oil, inspect for metallic material. Refill with manufacturer's recommended lubricant 2. Oil Filter — Replace with new 3. Lubricate all lube points of undercarriage 4. Clean battery terminals and install anti-corrosion washers 5. Check and fill all fluid levels 6, Inspect all drive belts and advise 7. Inspect tie rod ends and advise 8. Inspect tire wear and advise 9. Fill all tires to manufacturer’s recommended air pressure 10. Inspect exhaust system 11. inspect undercarriage area for potential leaks (oil, antifreeze, power steering fluid, etc.) 12. Inspect all hoses for wear and advise 13. inspect heater valves for potential leaks and overall operation 14. Inspect all emergency lighting and sirens for functionality 15. Inspect chassis lights (headlights, turn signals, interior dome fights, etc.) 16. Inspect brake pads 17. Inspect HVAC system in cab and module for overall operation 18. Inspect wheel chair lift operation. 19. Road test vehicle and advise 20. Inspect passenger compartment and advise of all deficiencies B. Preventative Maintenance at 10,000-mile intervals 1. Inspect tires for wear and advise 2. Rotate tires 3. Fill all tires to manufacturer's recommended air pressure 4. Check front end alignment and advise 5. Inspect brakes, note wear and advise 6. Check kingpins and advise 7. Inspect tie rod ends and advise 8. Service transmission and replace screen 9. Service rear differential and add rear additive 10. Air Filter — Replace with new 11. Fuel Filter — Replace with new 12, Check glow plug circuit (if applicable) and advise 13. Align headlights as needed 14, Inspect and lube rear step bumper area 15, Inspect all U-joints and advise 16. Inspect steering linkage 17. Road test vehicle and advise Exceptions: Yes No